油泥對自動攪拌一體車的影響都有哪些,今天我們來了解一下。
What are the effects of sludge on the automatic mixer truck? Let's have a look at it today.
自動攪拌一體車通常用于建筑行業,使用時無法避免污泥。這是污泥如何影響它。
Automatic mixer truck is usually used in construction industry, and sludge cannot be avoided. This is how the sludge affects it.
1.發動機尾氣排放降低,火花塞,氧傳感器和三效催化劑的使用壽命也縮短。
1. The engine exhaust emission is reduced, and the service life of spark plug, oxygen sensor and three-way catalyst is also shortened.
2.發動機功率降低,加速不平穩,油耗增加。
2. The engine power is reduced, the acceleration is not stable, and the fuel consumption is increased.
3.自動攪拌一體車的冷啟動很困難。冷車的怠速無法達到規定的速度。在嚴重的情況下,冷車的怠速將被關閉,并且熱車之后的怠速低。
3. It is very difficult to start the automatic mixer. The idle speed of the cold car cannot reach the specified speed. In severe cases, the idle speed of the cold car will be turned off, and the idle speed after the hot car will be low.
4.積碳也會(huì )使發動機的活塞環卡住,影響活塞環的密封性能,自動攪拌一體車的油耗會(huì )增加,導致發動機燃燒油,縮短使用壽命引擎。
4. Carbon deposition will also cause the piston ring of the engine to jam and affect the sealing performance of the piston ring. The fuel consumption of the automatic mixing vehicle will increase, resulting in the engine burning oil and shortening the service life of the engine.

以上是污泥對自動攪拌一體車的影響,因此在使用自動攪拌一體車后應進行清洗,以防止污泥堆積。
The above is the impact of sludge on the automatic mixer truck, so it should be cleaned after using the automatic mixer to prevent sludge accumulation.
自動攪拌一體車的日常清潔步驟
Daily cleaning steps of automatic mixer truck
每天必須清洗自動攪拌一體車,自動攪拌一體車凝固,如果需要很長時間,會(huì )導致腐蝕。如果長時間不干凈,汽車會(huì )變得越來越重。以下是每個人的日常清潔程序。
The automatic mixer truck must be cleaned every day. If it takes a long time, it will cause corrosion. If it is not clean for a long time, the car will become heavier and heavier. Here is everyone's daily cleaning procedure.
1.每次灌裝前用水沖洗進料口,以便在灌裝過程中保持進料口濕潤;
1. Flush the feed inlet with water before each filling, so as to keep the feed inlet moist during the filling process;
2.在裝載的同時,將裝有車輛的洗滌水箱裝滿水;
2. At the same time of loading, fill the washing water tank of the vehicle with water;
3.充電后,沖洗進料口,清潔進料口附近的混凝土;
3. After charging, flush the feed port and clean the concrete near the feed inlet;
4.在施工現場卸貨后,沖洗排水罐,然后在自動攪拌一體車中加入30-40L洗滌水;當車輛返回時,保持混凝土罐緩慢旋轉;
4. After unloading at the construction site, wash the drainage tank, and then add 30-40l washing water into the automatic mixing truck; when the vehicle returns, keep the concrete tank slowly rotating;
5.記得在下次裝貨前將污水放入自動混凝土攪拌罐中;
5. Remember to put the sewage into the automatic concrete mixing tank before the next loading;
6.每天徹底清潔自動攪拌一體車攪拌槽和工作周?chē)倪M(jìn)出口,確保沒有水泥和混凝土結塊。
6. Thoroughly clean the mixing tank of the automatic mixer truck and the inlet and outlet around the work area every day to ensure that there is no cement and concrete caking.
自動攪拌一體車必須注意正常清潔。如果長時間不清潔,會(huì )對車輛造成損壞,大大縮短自動自動攪拌一體車的使用壽命。
Attention must be paid to the normal cleaning of the automatic mixer. If it is not cleaned for a long time, it will damage the vehicle and greatly shorten the service life of the automatic mixing vehicle.
自動攪拌一體車的油泥影響問題介紹就是這樣了,希望對你有幫助。
This is the introduction of the sludge influence of the automatic mixer. I hope it can help you.